-
Tuning the mechanical properties of organophilic clay dispersions: particle composition and preshear history effects
Authors:
Nikolaos A. Burger,
Benoit Loppinet,
Andrew Clarke,
George Petekidis
Abstract:
Clay minerals are abundant natural materials used widely in coatings, construction materials, ceramics, as well as being a component of drilling fluids. Here, we present the effect of steady and oscillatory preshear on organophilic modified clay gels in synthetic oil. Both platelet and needle-like particles are used as viscosifiers in drilling fluid formulations. For both particles the plateau mod…
▽ More
Clay minerals are abundant natural materials used widely in coatings, construction materials, ceramics, as well as being a component of drilling fluids. Here, we present the effect of steady and oscillatory preshear on organophilic modified clay gels in synthetic oil. Both platelet and needle-like particles are used as viscosifiers in drilling fluid formulations. For both particles the plateau modulus exhibits a similar concentration dependence, G_P ~ c^3.9, whereas the yield strain is γ_y ~ c^(-1) for the platelets and γ_y ~ c^-1.7 for the needles. Mixtures of the two follow an intermediate behavior: at low concentrations their elasticity and yield strain follows that of needle particles while at higher concentrations it exhibits a weaker power law dependence. Furthermore, upon varying the preshear history, the gel viscoelastic properties can be significantly tuned. At lower (higher) clay concentrations, preshear at specific oscillatory strain amplitudes or steady shear rates, may induce a hardening (softening) of the dispersions and, at all concentrations, a lowering of the shear strain. Hence, in needle dispersions preshear resulted in changes in the volume fraction dependence of the elastic modulus from G_P ~ c^3.9 to G_P ~ c^2.5 and of the yield strain from γ_y ~ c^-1.7 to γ_y ~ c^-1. However, small angle X-ray scattering showed not much structural changes, within the q-range covered. Our findings indicate ways to design colloidal organoclay dispersions with a mechanical response that can be tuned at will.
△ Less
Submitted 17 August, 2024;
originally announced August 2024.
-
High-frequency Optimally Windowed Chirp rheometry for rapidly evolving viscoelastic materials: application to a crosslinking thermoset
Authors:
Thanasis Athanasiou,
Michela Geri,
Patrice Roose,
Gareth H. McKinley,
George Petekidis
Abstract:
Abstract
Knowledge of the evolution of mechanical properties of the curing matrix is of great importance in composite parts or structure fabrication. Conventional rheometry, based on small amplitude oscillatory shear is limited by long interrogation times. In rapidly evolving materials, time sweeps can provide a meaningful measurement albeit at a single frequency. To overcome this constraint we…
▽ More
Abstract
Knowledge of the evolution of mechanical properties of the curing matrix is of great importance in composite parts or structure fabrication. Conventional rheometry, based on small amplitude oscillatory shear is limited by long interrogation times. In rapidly evolving materials, time sweeps can provide a meaningful measurement albeit at a single frequency. To overcome this constraint we utilize a combined frequency and amplitude-modulated chirped strain waveform in conjunction with a home-made sliding plate piezo-operated (PZR) and a dual-head commercial rotational rheometer (Anton Paar MCR 702) to probe the linear viscoelasticity of these time-evolving materials. The direct controllability of the PZR resulting from the absence of any kind of firmware and the microsecond actuator-sensor response renders this device ideal for exploring the advantages of this technique. The high frequency capability allows us to extend the upper limits of the accessible linear viscoelastic spectrum and most importantly, to shorten the length of the interrogating strain signal (OWCh-PZR) to sub-second scales, while retaining a high time-bandwidth product. This short duration ensures that the mutation number (NMu) is kept sufficiently low, even in fast curing resins. The method is validated via calibration tests in both instruments and the corresponding limitations are discussed. As a proof of concept the technique is applied to a curing vinylester resin. The linear viscoelastic (LVE) spectrum is assessed every 20 seconds to monitor the rapid evolution of the time- and frequency-dependence of the complex modulus. Finally, FTIR spectroscopy is utilized to gain insights on the evolution of the chemical network while the gap-dependence of the evolving material properties in these heterogeneous systems is also investigated.
△ Less
Submitted 13 May, 2024;
originally announced May 2024.
-
Yielding under the microscope: a multi-scale perspective on brittle and ductile behaviors in oscillatory shear
Authors:
P. Edera,
M. Brizioli,
M. Madani,
E. Ngouamba,
P. Coussot,
V. Trappe,
G. Petekidis,
F. Giavazzi,
R. Cerbino
Abstract:
We study the yielding transition in soft jammed materials under oscillatory shear, employing a novel methodology that combines rheological measurements with detailed dynamical observations. This method provides a comprehensive view of the intricate interactions between macroscopic mechanical behavior, mesoscopic deformation patterns, and microscopic dynamics during yielding. Our findings reveal tw…
▽ More
We study the yielding transition in soft jammed materials under oscillatory shear, employing a novel methodology that combines rheological measurements with detailed dynamical observations. This method provides a comprehensive view of the intricate interactions between macroscopic mechanical behavior, mesoscopic deformation patterns, and microscopic dynamics during yielding. Our findings reveal two distinct yielding behaviors: at one end, a smooth, uniform transition, characterized by homogeneous strain fields, and Fickian, Gaussian microscopic dynamics; at the other, a sharp transition defined by pronounced shear banding, with the dynamics within shear bands being governed exclusively by the local strain, and exhibiting non-Gaussian, cooperative nature. The viscoplastic fragility emerges as a key macroscopic predictor of these intricate behaviors across micro- and meso-scales, providing a new perspective to understand and quantify ductile and brittle yielding in soft materials.
△ Less
Submitted 31 January, 2024;
originally announced February 2024.
-
On the Nature of Flow Curve and Categorization of Thixotropic Yield Stress Materials
Authors:
Tulika Bhattacharyya,
Alan R. Jacob,
George Petekidis,
Yogesh M. Joshi
Abstract:
Thixotropy is a phenomenon related to time dependent change in viscosity in presence or absence of flow. The yield stress, on the other hand, represents the minimum value of stress above which steady flow can be sustained. In addition, the yield stress of a material may also change as a function of time. Both these characteristic features in a material strongly influence the steady state flow curv…
▽ More
Thixotropy is a phenomenon related to time dependent change in viscosity in presence or absence of flow. The yield stress, on the other hand, represents the minimum value of stress above which steady flow can be sustained. In addition, the yield stress of a material may also change as a function of time. Both these characteristic features in a material strongly influence the steady state flow curve of the same. This study aims to understand the interrelation between thixotropy, yield stress and their relation with the flow curve. In this regard, we study five thixotropic materials that show yield stress. The relaxation time of all the five systems shows power-law dependence on aging time with behaviors ranging from weaker than linear, linear to stronger than linear. Furthermore, the elastic modulus and yield stress has been observed to be constant for some systems while time dependent for the others. We also analyze the experimental behavior through a viscoelastic thixotropic structural kinetic model that predicts the observed experimental behavior of constant as well as time-dependent yield stress quite well. These findings indicate that a non-monotonic steady-state flow curve in a structural kinetic formalism necessarily leads to time-dependent yield stress, while constant yield stress is predicted by a monotonic steady-state flow curve with stress plateau in the limit of low shear rates. The present work, therefore, shows that thixotropic materials may exhibit either monotonic or non-monotonic flow curves. Consequently, thixotropic materials may show no yield stress, constant yield stress or time-dependent yield stress.
△ Less
Submitted 12 January, 2023; v1 submitted 8 September, 2022;
originally announced September 2022.
-
Shear induced tuning and memory effects in colloidal gels of rods and spheres
Authors:
Mohan Das,
George Petekidis
Abstract:
Shear history plays an important role in determining the linear and nonlinear rheological response of colloidal gels and can be used for tuning their structure and flow properties. Increasing colloidal particle aspect ratio lowers the critical volume fraction for gelation due to an increase of the particle excluded volume. Using a combination of rheology and confocal microscopy we investigate the…
▽ More
Shear history plays an important role in determining the linear and nonlinear rheological response of colloidal gels and can be used for tuning their structure and flow properties. Increasing colloidal particle aspect ratio lowers the critical volume fraction for gelation due to an increase of the particle excluded volume. Using a combination of rheology and confocal microscopy we investigate the effect of steady and oscillatory pre-shear history on the structure and rheology of colloidal gels formed by silica spheres and rods of length L and diameter D (L/D = 10) dispersed in 11 M CsCl solution. We use a non-dimensional Mason number, Mn (= F_visc./F_attr.) to compare the effect of steady and oscillatory pre-shear on gel viscoelasticity. We show that after pre-shearing at intermediate Mn, attractive sphere gel exhibits strengthening whereas attractive rod gel exhibits weakening. Rheo-imaging of gels of attractive rods shows that at intermediate Mn, oscillatory pre-shear induces large compact rod clusters in the gel microstructure, compared to steady pre-shear. Our study highlights the impact of particle shape on gel structuring under flow and viscoelasticity after shear cessation.
△ Less
Submitted 11 July, 2022;
originally announced July 2022.
-
Tuning local microstructure of colloidal gels by ultrasound-activated deformable inclusions
Authors:
Brice Saint-Michel,
George Petekidis,
Valeria Garbin
Abstract:
Colloidal gels possess a memory of previous shear events, both steady and oscillatory. This memory, embedded in the microstructure, affects the mechanical response of the gel, and therefore enables precise tuning of the material properties under careful preparation. Here we demonstrate how the dynamics of a deformable inclusion, namely a bubble, can be used to locally tune the microstructure of a…
▽ More
Colloidal gels possess a memory of previous shear events, both steady and oscillatory. This memory, embedded in the microstructure, affects the mechanical response of the gel, and therefore enables precise tuning of the material properties under careful preparation. Here we demonstrate how the dynamics of a deformable inclusion, namely a bubble, can be used to locally tune the microstructure of a colloidal gel. We examine two different phenomena of bubble dynamics that apply a local strain to the surrounding material: dissolution due to mass transfer, with a characteristic strain rate of $10^{-3}$ s$^{-1}$; and volumetric oscillations driven by ultrasound, with a characteristic frequency of $10^4$ s$^{-1}$.
We characterise experimentally the microstructure of a model colloidal gel around bubbles in a Hele-Shaw geometry using confocal microscopy and particle tracking. In bubble dissolution experiments, we observe the formation of a pocket of solvent next to the bubble surface, but marginal changes to the microstructure. In experiments with ultrasound-induced bubble oscillations, we observe a striking rearrangement of the gel particles into a microstructure with increased local ordering. High-speed bright-field microscopy reveals the occurrence of both high-frequency bubble oscillations and steady microstreaming flow; both are expected to contribute to the emergence of the local order in the microstructure. These observations open the way to local tuning of colloidal gels based on deformable inclusions controlled by external pressure fields.
△ Less
Submitted 15 December, 2021; v1 submitted 14 December, 2021;
originally announced December 2021.
-
Deformation profiles and microscopic dynamics of complex fluids during oscillatory shear experiments
Authors:
Paolo Edera,
Matteo Brizioli,
Giuliano Zanchetta,
George Petekidis,
Fabio Giavazzi,
Roberto Cerbino
Abstract:
Oscillatory shear tests are widely used in rheology to characterize the linear and non-linear mechanical response of complex fluids, including the yielding transition. There is an increasing urge to acquire detailed knowledge of the deformation field that is effectively present across the sample during these tests; at the same time, there is mounting evidence that the macroscopic rheological respo…
▽ More
Oscillatory shear tests are widely used in rheology to characterize the linear and non-linear mechanical response of complex fluids, including the yielding transition. There is an increasing urge to acquire detailed knowledge of the deformation field that is effectively present across the sample during these tests; at the same time, there is mounting evidence that the macroscopic rheological response depends on the elusive microscopic behavior of the material constituents. Here we employ a strain-controlled shear-cell with transparent walls to visualize and quantify the dynamics of tracers embedded in various cyclically sheared complex fluids, ranging from almost-ideal elastic to yield stress fluids. For each sample, we use image correlation processing to measure the macroscopic deformation field, and echo-Differential Dynamic Microscopy to probe the microscopic irreversible sample dynamics in reciprocal space; finally, we devise a simple scheme to spatially map the rearrangements in the sheared sample, once again without tracking the tracers. For the yield stress sample, we obtain a wave-vector dependent characterization of shear-induced diffusion across the yielding transition, which is accompanied by a three-order-of-magnitude speed-up of the dynamics and by a transition from localized, intermittent rearrangements to a more spatially homogeneous and temporally uniform activity. Our tracking free approach is intrinsically multi-scale, can successfully discriminate between different types of dynamics, and can be automated to minimize user intervention. Applications are many, as it can be translated to other imaging modes, including fluorescence, and can be used with sub-resolution tracers and even without tracers, for samples that provide intrinsic optical contrast.
△ Less
Submitted 19 August, 2021; v1 submitted 20 July, 2021;
originally announced July 2021.
-
Dilatancy in dense suspensions of model hard-sphere-like colloids under shear and extensional flow
Authors:
Ricardo J. E. Andrade,
Alan R. Jacob,
Francisco J. Galindo-Rosales,
Laura Campo-Deapo,
Qian Huang,
Ole Hassager,
George Petekidis
Abstract:
Dense suspensions of model hard-sphere-like colloids, with different particle sizes, are examined experimentally in the glass state, under shear and extensional rheology. Under steady shear flow we detect Discontinuous Shear Thickening (DST) above a critical shear rate. Start-up shear experiments show stress overshoots in the vicinity of the onset of DST related with a change in microscopic morpho…
▽ More
Dense suspensions of model hard-sphere-like colloids, with different particle sizes, are examined experimentally in the glass state, under shear and extensional rheology. Under steady shear flow we detect Discontinuous Shear Thickening (DST) above a critical shear rate. Start-up shear experiments show stress overshoots in the vicinity of the onset of DST related with a change in microscopic morphology, as the sample shows dilatancy effects. The analysis of the normal stress together with direct sample observation by high speed camera, indicates the appearance of positive N1 and dilation behavior at the shear thickening onset. Dilatancy effects are detected also under extensional flow. The latter was studied through capillary breakup and filament stretching experimental setups, where liquid-like response is seen for strain rate lower than a critical strain rate and solid like-behavior for higher strain rates. Monitoring the filament thinning processes under different conditions (volume fractions and strain rates) we have created a state diagram where all responses of a hard-sphere suspension (Newtonian, shear thinning, shear thickening, dilatant) are shown. We finally compare the shear thickening response of these hard-sphere-like suspensions and glasses in shear with that in extensional flow.
△ Less
Submitted 8 July, 2020;
originally announced July 2020.
-
Colloidal Gels Tuned by Oscillatory Shear
Authors:
E. Moghimi,
A. R. Jacob,
N. Koumakis,
G. Petekidis
Abstract:
We examine microstructural and mechanical changes which occur during oscillatory shear flow and reformation after flow cessation of an intermediate volume fraction colloidal gel using rheometry and Brownian Dynamics (BD) simulations. A model depletion colloid-polymer mixture is used, comprising of a hard sphere colloidal suspension with the addition of non-adsorbing linear polymer chains. Results…
▽ More
We examine microstructural and mechanical changes which occur during oscillatory shear flow and reformation after flow cessation of an intermediate volume fraction colloidal gel using rheometry and Brownian Dynamics (BD) simulations. A model depletion colloid-polymer mixture is used, comprising of a hard sphere colloidal suspension with the addition of non-adsorbing linear polymer chains. Results reveal three distinct regimes depending on the strain amplitude of oscillatory shear. Large shear strain amplitudes fully break the structure which results into a more homogenous and stronger gel after flow cessation. Intermediate strain amplitudes densify the clusters and lead to highly heterogeneous and weak gels. Shearing the gel to even lower strain amplitudes creates a less heterogonous stronger solid. These three regimes of shearing are connected to the microscopic shear-induced structural heterogeneity. A comparison with steady shear flow reveals that the latter does not produce structural heterogeneities as large as oscillatory shear. Therefore oscillatory shear is a much more efficient way of tuning the mechanical properties of colloidal gels. Moreover, colloidal gels presheared at large strain amplitudes exhibit a distinct nonlinear response characterized largely by a single yielding process while in those presheared at lower rates a two step yield process is promoted due to the creation of highly heterogeneous structures.
△ Less
Submitted 10 July, 2017; v1 submitted 7 July, 2017;
originally announced July 2017.
-
Start-up Shear of Concentrated Colloidal Hard Spheres: Stresses, Dynamics and Structure
Authors:
N. Koumakis,
M. Laurati,
A. R. Jacob,
K. J. Mutch,
A. Abdellali,
A. B. Schofield,
S. U. Egelhaaf,
J. F. Brady,
G. Petekidis
Abstract:
The transient response of model hard sphere glasses is examined during the application of steady rate start-up shear using Brownian Dynamics (BD) simulations, experimental rheology and confocal microscopy. With increasing strain the glass initially exhibits an almost linear elastic stress increase, a stress peak at the yield point and then reaches a constant steady state. The stress overshoot has…
▽ More
The transient response of model hard sphere glasses is examined during the application of steady rate start-up shear using Brownian Dynamics (BD) simulations, experimental rheology and confocal microscopy. With increasing strain the glass initially exhibits an almost linear elastic stress increase, a stress peak at the yield point and then reaches a constant steady state. The stress overshoot has a non-monotonic dependence with Peclet number, Pe, and volume fraction, φ, determined by the available free volume and a competition between structural relaxation and shear advection. Examination of the structural properties under shear revealed an increasing anisotropic radial distribution function, g(r), mostly in the velocity - gradient (xy) plane, which decreases after the stress peak with considerable anisotropy remaining in the steady-state. Low rates minimally distort the structure, while high rates show distortion with signatures of transient elongation. As a mechanism of storing energy, particles are trapped within a cage distorted more than Brownian relaxation allows, while at larger strains, stresses are relaxed as particles are forced out of the cage due to advection. Even in the steady state, intermediate super diffusion is observed at high rates and is a signature of the continuous breaking and reformation of cages under shear.
△ Less
Submitted 7 July, 2017;
originally announced July 2017.
-
Amorphous and ordered states of concentrated hard spheres under oscillatory shear
Authors:
Nick Koumakis,
John F. Brady,
George Petekidis
Abstract:
Hard sphere colloidal particles are a basic model system for general research into phase behavior, ordering and out-equilibrium glass transitions. Experimentally it has been shown that oscillatory shearing of a monodisperse hard sphere glass, produces two different crystal orientations; a Face Centered Cubic (FCC) crystal with the close packed direction parallel to shear at high strains and an FCC…
▽ More
Hard sphere colloidal particles are a basic model system for general research into phase behavior, ordering and out-equilibrium glass transitions. Experimentally it has been shown that oscillatory shearing of a monodisperse hard sphere glass, produces two different crystal orientations; a Face Centered Cubic (FCC) crystal with the close packed direction parallel to shear at high strains and an FCC crystal with the close packed direction perpendicular to shear at low strains. Here, using Brownian dynamics simulations of hard sphere particles, we have examined high volume fraction shear-induced crystals under oscillatory shear as well as the same volume fraction glass counterparts. We find that, while the displacements under shear of the glass are isotropic, the sheared FCC crystal structures oriented parallel to shear, are anisotropic due to the cooperative motion of velocity-vorticity layers of particles sliding over each other. These sliding layers generally result in lower stresses and less overall particle displacements. Additionally, from the two crystal types, the perpendicular crystal exhibits less stresses and displacements at smaller strains, however at larger strains, the sliding layers of the parallel crystal are found to be more efficient in minimizing stresses and displacements, while the perpendicular crystal becomes unstable. The findings of this work suggest that the process of shear-induced ordering for a colloidal glass is facilitated by large out of cage displacements, which allow the system to explore the energy landscape and find the minima in energy, stresses and displacements by configuring particles into a crystal oriented parallel to shear.
△ Less
Submitted 12 January, 2016;
originally announced January 2016.
-
Residual Stresses in Glasses
Authors:
M. Ballauff,
J. M. Brader,
S. U. Egelhaaf,
M. Fuchs,
J. Horbach,
N. Koumakis,
M. Krüger,
M. Laurati,
K. J. Mutch,
G. Petekidis,
M. Siebenbürger,
Th. Voigtmann,
J. Zausch
Abstract:
The history dependence of the glasses formed from flow-melted steady states by a sudden cessation of the shear rate $\dotγ$ is studied in colloidal suspensions, by molecular dynamics simulations, and mode-coupling theory. In an ideal glass, stresses relax only partially, leaving behind a finite persistent residual stress. For intermediate times, relaxation curves scale as a function of $\dotγt$, e…
▽ More
The history dependence of the glasses formed from flow-melted steady states by a sudden cessation of the shear rate $\dotγ$ is studied in colloidal suspensions, by molecular dynamics simulations, and mode-coupling theory. In an ideal glass, stresses relax only partially, leaving behind a finite persistent residual stress. For intermediate times, relaxation curves scale as a function of $\dotγt$, even though no flow is present. The macroscopic stress evolution is connected to a length scale of residual liquefaction displayed by microscopic mean-squared displacements. The theory describes this history dependence of glasses sharing the same thermodynamic state variables, but differing static properties.
△ Less
Submitted 15 February, 2013;
originally announced February 2013.
-
Complex oscillatory yielding of model hard sphere glasses
Authors:
N. Koumakis,
J. F. Brady,
G. Petekidis
Abstract:
The yielding behaviour of hard sphere glasses under large amplitude oscillatory shear has been studied by probing the interplay of Brownian motion and shear-induced diffusion at varying oscillation frequencies. Stress, structure and dynamics are followed by experimental rheology and Browian Dynamics simulations. Brownian motion assisted cage escape dominates at low frequencies while escape through…
▽ More
The yielding behaviour of hard sphere glasses under large amplitude oscillatory shear has been studied by probing the interplay of Brownian motion and shear-induced diffusion at varying oscillation frequencies. Stress, structure and dynamics are followed by experimental rheology and Browian Dynamics simulations. Brownian motion assisted cage escape dominates at low frequencies while escape through shear-induced collisions at high ones, both related with a yielding peak in\ $G^{\prime \prime}$. At intermediate frequencies a novel, for HS glasses, double peak in $G^{\prime \prime}$ is revealed reflecting both mechanisms. At high frequencies and strain amplitudes a persistent structural anisotropy causes a stress drop within the cycle after strain reversal, while higher stress harmonics are minimized at certain strain amplitudes indicating an apparent harmonic response.
△ Less
Submitted 6 February, 2013;
originally announced February 2013.
-
Yielding of binary colloidal glasses
Authors:
T. Sentjabrskaja,
E. Babaliari,
J. Hendricks,
M. Laurati,
G. Petekidis,
S. U. Egelhaaf
Abstract:
The rheological response, in particular the non-linear response, to oscillatory shear is experimentally investigated in colloidal glasses. The glasses are highly concentrated binary hard-sphere mixtures with relatively large size disparities. For a size ratio of 0.2, a strong reduction of the normalized elastic moduli, the yield strain and stress and, for some samples, even melting of the glass to…
▽ More
The rheological response, in particular the non-linear response, to oscillatory shear is experimentally investigated in colloidal glasses. The glasses are highly concentrated binary hard-sphere mixtures with relatively large size disparities. For a size ratio of 0.2, a strong reduction of the normalized elastic moduli, the yield strain and stress and, for some samples, even melting of the glass to a fluid is observed upon addition of the second species. This is attributed to the more efficient packing, as indicated by the shift of random close packing to larger total volume fractions. This leads to an increase in free volume which favours cage deformations and hence a loosening of the cage. Cage deformations are also favoured by the structural heterogeneity introduced by the second species. For a limited parameter range, we furthermore found indications of two-step yielding, as has been reported previously for attractive glasses. In samples containing spheres with more comparable sizes, namely a size ratio of 0.38, the cage seems less distorted and structural heterogeneities on larger length scales seem to become important. The limited structural changes are reflected in only a small reduction of the moduli, yield strain and stress.
△ Less
Submitted 11 March, 2013; v1 submitted 31 January, 2013;
originally announced January 2013.
-
Wall slip and flow of concentrated hard-sphere colloidal suspensions
Authors:
P. Ballesta,
G. Petekidis,
L. Isa,
W. C. K. Poon,
R. Besseling
Abstract:
We present a comprehensive study of the slip and flow of concentrated colloidal suspensions using cone-plate rheometry and simultaneous confocal imaging. In the colloidal glass regime, for smooth, non-stick walls, the solid nature of the suspension causes a transition in the rheology from Herschel-Bulkley (HB) bulk flow behavior at large stress to a Bingham-like slip behavior at low stress, which…
▽ More
We present a comprehensive study of the slip and flow of concentrated colloidal suspensions using cone-plate rheometry and simultaneous confocal imaging. In the colloidal glass regime, for smooth, non-stick walls, the solid nature of the suspension causes a transition in the rheology from Herschel-Bulkley (HB) bulk flow behavior at large stress to a Bingham-like slip behavior at low stress, which is suppressed for sufficient colloid-wall attraction or colloid-scale wall roughness. Visualization shows how the slip-shear transition depends on gap size and the boundary conditions at both walls and that partial slip persist well above the yield stress. A phenomenological model, incorporating the Bingham slip law and HB bulk flow, fully accounts for the behavior. Microscopically, the Bingham law is related to a thin (sub-colloidal) lubrication layer at the wall, giving rise to a characteristic dependence of slip parameters on particle size and concentration. We relate this to the suspension's osmotic pressure and yield stress and also analyze the influence of van der Waals interaction. For the largest concentrations, we observe non-uniform flow around the yield stress, in line with recent work on bulk shear-banding of concentrated pastes. We also describe residual slip in concentrated liquid suspensions, where the vanishing yield stress causes coexistence of (weak) slip and bulk shear flow for all measured rates.
△ Less
Submitted 20 January, 2012;
originally announced January 2012.
-
Shear banding and flow-concentration coupling in colloidal glasses
Authors:
R. Besseling,
L. Isa,
P. Ballesta,
G. Petekidis,
M. E. Cates,
W. C. K. Poon
Abstract:
We report experiments on hard sphere colloidal glasses that reveal a type of shear banding hitherto unobserved in soft glasses. We present a scenario that relates this to an instability arising from shear-concentration coupling, a mechanism previously thought unimportant in this class of materials. Below a characteristic shear rate $\dotγ_c$ we observe increasingly non-linear velocity profiles and…
▽ More
We report experiments on hard sphere colloidal glasses that reveal a type of shear banding hitherto unobserved in soft glasses. We present a scenario that relates this to an instability arising from shear-concentration coupling, a mechanism previously thought unimportant in this class of materials. Below a characteristic shear rate $\dotγ_c$ we observe increasingly non-linear velocity profiles and strongly localized flows. We attribute this trend to very slight concentration gradients (likely to evade direct detection) arising in the unstable flow regime. A simple model accounts for both the observed increase of $\dotγ_c$ with concentration, and the fluctuations observed in the flow.
△ Less
Submitted 24 November, 2010; v1 submitted 8 September, 2010;
originally announced September 2010.
-
Brambilla, et al. Reply
Authors:
Giovanni Brambilla,
Djamel El Masri,
Matteo Pierno,
Ludovic Berthier,
Luca Cipelletti,
George Petekidis,
Andrew B. Schofield
Abstract:
Brambilla, et al. Reply: van Megen and Williams (vMW) question our recent claim that dense colloidal hard spheres enter at large volume fraction φa dynamical regime not observed in earlier work and not described by the mode-coupling theory (MCT) of the glass transition.
Brambilla, et al. Reply: van Megen and Williams (vMW) question our recent claim that dense colloidal hard spheres enter at large volume fraction φa dynamical regime not observed in earlier work and not described by the mode-coupling theory (MCT) of the glass transition.
△ Less
Submitted 27 August, 2010;
originally announced August 2010.
-
Dynamic light scattering measurements in the activated regime of dense colloidal hard spheres
Authors:
Djamel El Masri,
Giovanni Brambilla,
Matteo Pierno,
George Petekidis,
Andrew Schofield,
Ludovic Berthier,
Luca Cipelletti
Abstract:
We use dynamic light scattering and numerical simulations to study the approach to equilibrium and the equilibrium dynamics of systems of colloidal hard spheres over a broad range of density, from dilute systems up to very concentrated suspensions undergoing glassy dynamics. We discuss several experimental issues (sedimentation, thermal control, non-equilibrium aging effects, dynamic heterogenei…
▽ More
We use dynamic light scattering and numerical simulations to study the approach to equilibrium and the equilibrium dynamics of systems of colloidal hard spheres over a broad range of density, from dilute systems up to very concentrated suspensions undergoing glassy dynamics. We discuss several experimental issues (sedimentation, thermal control, non-equilibrium aging effects, dynamic heterogeneity) arising when very large relaxation times are measured. When analyzed over more than seven decades in time, we find that the equilibrium relaxation time, tau_alpha, of our system is described by the algebraic divergence predicted by mode-coupling theory over a window of about three decades. At higher density, tau_alpha increases exponentially with distance to a critical volume fraction phi_0 which is much larger than the mode-coupling singularity. This is reminiscent of the behavior of molecular glass-formers in the activated regime. We compare these results to previous work, carefully discussing crystallization and size polydispersity effects. Our results suggest the absence of a genuine algebraic divergence of tau_alpha in colloidal hard spheres.
△ Less
Submitted 11 March, 2009;
originally announced March 2009.
-
Rheology, Structure and Dynamics of Colloid-Polymer Mixtures: from Liquids to Gels
Authors:
M. Laurati,
G. Petekidis,
N. Koumakis,
F. Cardinaux,
A. B. Schofield,
J. M. Brader,
M. Fuchs,
S. U. Egelhaaf
Abstract:
We investigated the viscoelastic properties of colloid-polymer mixtures at intermediate colloid volume fraction and varying polymer concentrations, thereby tuning the attractive interactions. Within the examined range of polymer concentrations, the samples ranged from fluids to gels. Already in the liquid phase the viscoelastic properties significantly changed when approaching the gelation bound…
▽ More
We investigated the viscoelastic properties of colloid-polymer mixtures at intermediate colloid volume fraction and varying polymer concentrations, thereby tuning the attractive interactions. Within the examined range of polymer concentrations, the samples ranged from fluids to gels. Already in the liquid phase the viscoelastic properties significantly changed when approaching the gelation boundary, indicating the formation of clusters and transient networks. This is supported by an increasing correlation length of the density fluctuations, observed by static light scattering and microscopy. At the same time, the correlation function determined by dynamic light scattering completely decays, indicating the absence of dynamical arrest. Upon increasing the polymer concentration beyond the gelation boundary, the rheological properties changed qualitatively again, now they are consistent with the formation of colloidal gels. Our experimental results, namely the location of the gelation boundary as well as the elastic (storage) and viscous (loss) moduli, are compared to different theoretical models. These include consideration of the escape time as well as predictions for the viscoelastic moduli based on scaling relations and Mode Coupling Theories (MCT).
△ Less
Submitted 4 December, 2008;
originally announced December 2008.
-
Probing the equilibrium dynamics of colloidal hard spheres above the mode-coupling glass transition
Authors:
Giovanni Brambilla,
Djamel El Masri,
Matteo Pierno,
Ludovic Berthier,
Luca Cipelletti,
George Petekidis,
Andrew B. Schofield
Abstract:
We use dynamic light scattering and computer simulations to study equilibrium dynamics and dynamic heterogeneity in concentrated suspensions of colloidal hard spheres. Our study covers an unprecedented density range and spans seven decades in structural relaxation time, $\ta$, including equilibrium easurements above $φ_{\rm c}$, the location of the glass transition deduced from fitting our data…
▽ More
We use dynamic light scattering and computer simulations to study equilibrium dynamics and dynamic heterogeneity in concentrated suspensions of colloidal hard spheres. Our study covers an unprecedented density range and spans seven decades in structural relaxation time, $\ta$, including equilibrium easurements above $φ_{\rm c}$, the location of the glass transition deduced from fitting our data to mode-coupling theory. Instead of falling out of equilibrium, the system remains ergodic above $φ_{\rm c}$ and enters a new dynamical regime where $\ta$ increases with a functional form that was not anticipated by previous experiments, while the amplitude of dynamic heterogeneity grows slower than a power law with $\ta$, as found in molecular glass-formers close to the glass transition.
△ Less
Submitted 3 April, 2009; v1 submitted 19 September, 2008;
originally announced September 2008.
-
Slip and flow of hard-sphere colloidal glasses
Authors:
P. Ballesta,
R. Besseling,
L. Isa,
G. Petekidis,
W. C. K. Poon
Abstract:
We study the flow of concentrated hard-sphere colloidal suspensions along smooth, non-stick walls using cone-plate rheometry and simultaneous confocal microscopy. In the glass regime, the global flow shows a transition from Herschel-Bulkley behavior at large shear rate to a characteristic Bingham slip response at small rates, absent for ergodic colloidal fluids. Imaging reveals both the `solid'…
▽ More
We study the flow of concentrated hard-sphere colloidal suspensions along smooth, non-stick walls using cone-plate rheometry and simultaneous confocal microscopy. In the glass regime, the global flow shows a transition from Herschel-Bulkley behavior at large shear rate to a characteristic Bingham slip response at small rates, absent for ergodic colloidal fluids. Imaging reveals both the `solid' microstructure during full slip and the local nature of the `slip to shear' transition. Both the local and global flow are described by a phenomenological model, and the associated Bingham slip parameters exhibit characteristic scaling with size and concentration of the hard spheres.
△ Less
Submitted 13 November, 2008; v1 submitted 9 July, 2008;
originally announced July 2008.
-
Effects of Shear-Induced Crystallization on the Rheology and Ageing of Hard Sphere Glasses
Authors:
N. Koumakis,
A. B. Schofield,
G. Petekidis
Abstract:
The rheological properties of highly concentrated suspensions of hard-sphere particles are studied with particular reference to the rheological response of shear induced crystals. Using practically monodisperse hard spheres, we prepare shear induced crystals under oscillatory shear and examine their linear and non-linear mechanical response in comparison with their glassy counterparts at the sam…
▽ More
The rheological properties of highly concentrated suspensions of hard-sphere particles are studied with particular reference to the rheological response of shear induced crystals. Using practically monodisperse hard spheres, we prepare shear induced crystals under oscillatory shear and examine their linear and non-linear mechanical response in comparison with their glassy counterparts at the same volume fraction. It is evident, that shear-induced crystallization causes a significant drop in the elastic and viscous moduli due to structural rearrangements that ease flow. For the same reason the critical (peak of G'') and crossover (overlap of G' and G'') strain are smaller in the crystal compared to the glass at the same volume fraction. When, however the distance from the maximum packing in each state is taken into account the elastic modulus of the crystal is found to be larger than the glass at the same free volume suggesting a strengthened material due to long range order. Finally, shear induced crystals counter-intuitively exhibit similar rheological ageing to the glass (with a logarithmic increase of G'), indicating that the shear induced structure is not at thermodynamic equilibrium.
△ Less
Submitted 8 April, 2008;
originally announced April 2008.